Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 JOE'S CATERING INC. D/B/A/ TUCCI'S ITALIAN 		License/Permit #
 BB026
Street Address
1560 STATE RT. 50 NORTH
City/State
 BOURBONNAIS, IL 		ZIP Code
 60914
No. of Risk Factor/Intervention Violations 1
No. of Repeat Risk Factor/Intervention Violations 1
Date 01/28/2021
Time In 02:00 PM
Time Out 03:30 PM
Permit Holder
JOE'S CATERING, INC. 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized    
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition X X
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39   Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41   Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43 X In-use utensils: properly stored    
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45 X Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47   Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55 X Physical facilities installed, maintained & clean   X
56 X Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58   Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: JOE'S CATERING INC. D/B/A/ TUCCI'S ITALIAN Establishment #: BB026
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: QUAT 200 Heat: CHLORINE 100 °F
CFPM Verification (name, ID#, expiration date):
MICHELLE WEST
21156897
02/08/2026 		LORI DILLON
21739445
04/07/2025

01/01/1900

 

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
lemons 35.00°F brownies 42.00°F ground beef 38.00°F
cheese 41.00°F squid 40.00°F raviolies 0.00°F
chicken 0.00°F baked potatoe 42.00°F tomatoes 39.00°F
walk-in cooler 40.00°F white sauce 87.00°F  

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
23 PF 3-501.17 (A-B) (E-G): (A)Except when PACKAGING FOOD using a REDUCED OXYGEN PACKAGING method as specified under § 3-502.12, and except as specified in ¶¶ (E) and (F) of this section, refrigerated, READY-TO -EAT, TIME/TEMPERATURE CONTROL FOR SAFETY FOOD prepared and held in a FOOD ESTABLISHMENT for more than 24 hours shall be clearly marked to indicate the date or day by which the FOOD shall be consumed on the PREMISES, sold, or discarded when held at a temperature of 5ºC (41ºF) or less for a maximum of 7 days. The day of preparation shall be counted as Day 1. (B) Except as specified in ¶¶ (E) - (G) of this section, refrigerated, READY-TO-EAT TIME/TEMPERATURE CONTROL FOR SAFETY FOOD prepared and PACKAGED by a FOOD PROCESSING PLANT shall be clearly marked, at the time the original container is opened in a FOOD ESTABLISHMENT and if the FOOD is held for more than 24 hours, to indicate the date or day by which the FOOD shall be consumed on the PREMISES, sold, or discarded, based on the temperature and time combinations specified in ¶ (A) of this section and: (1) The day the original container is opened in the FOOD ESTABLISHMENT shall be counted as Day 1; and (2) The day or date marked by the FOOD ESTABLISHMENT may not exceed a manufacturer’s use-by date if the manufacturer determined the use-by date based on FOOD safety. (E) Paragraphs (A) and (B) of this section do not apply to individual meal portions served or rePACKAGED for sale from a bulk container upon a consumer’s request. (F) Paragraphs (A) and (B) of this section do not apply to SHELLSTOCK.  (G) Paragraph (B) of this section does not apply to the following FOODS prepared and PACKAGED by a FOOD PROCESSING PLANT inspected by a REGULATORY AUTHORITY: (1) Deli salads, such as ham salad, seafood salad, chicken salad, egg salad, pasta salad, potato salad, and macaroni salad, manufactured in accordance with 21 CFR 110 Current good manufacturing practice in manufacturing, packing, or holding human food; (2) Hard cheeses containing not more than 39% moisture as defined in 21 CFR 133 Cheeses and related cheese products, such as cheddar, gruyere, parmesan and reggiano, and romano; (3) Semi-soft cheeses containing more than 39% moisture, but not more than 50% moisture, as defined in 21 CFR 133 cheeses and related cheese products, such as blue, edam, gorgonzola, gouda, and monterey jack; (4) Cultured dairy products as defined in 21 CFR 131 Milk and cream, such as yogurt, sour cream, and buttermilk; (5) Preserved FISH products, such as pickled herring and dried or salted cod, and other acidified FISH products defined in 21 CFR 114 Acidified foods; (6) Shelf stable, dry fermented sausages, such as pepperoni and Genoa; and (7) Shelf stable salt-cured products such as prosciutto and Parma (ham).
Some of the food items in the reach in cooler and walk-in cooler were missing dates. Provide that once the food item is prepared that they are immediately marked with a label. - COS,Repeat (Correct By: Jan 28, 2021)
43 C 3-304.12 (C): During pauses in FOOD preparation or dispensing, FOOD preparation and dispensing UTENSILS shall be stored: (C) On a clean portion of the FOOD preparation table or cooking EQUIPMENT only if the in-use UTENSIL and the FOOD- CONTACT surface of the FOOD preparation table or cooking EQUIPMENT are cleaned and SANITIZED at a frequency specified under §§ 4-602.11 and 4-702.11.
Observed knives and utensils improperly stored 1) between the cutting board table and pizza prep units and 2)between the steam table and pre table. Correct and maintain by next routine inspection.
45 C 4-903.11( A)(1)(2)(3): (A) Except as specified in ¶ (D) of this section, cleaned EQUIPMENT and UTENSILS, laundered LINENS, and SINGLE-SERVICE and SINGLE-USE ARTICLES shall be stored: (1) In a clean, dry location; (2) Where they are not exposed to splash, dust, or other contamination; and (3) At least 15 cm (6 inches) above the floor.
Observed boxes of to-go containers to be stored directly on the floor. Correct and maintain by next routine inspection.
49 C 4-601.11(C): (C) NonFOOD-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris.
Gaskets to the cold prep cooler in the cook line were dirty. Clean and maintain by next routine inspection.
49 C 4-601.11(C): (C) NonFOOD-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris.
Inside of the utensil drawer next to the can opener had debris collecting at the bottom. Clean and maintain by next routine inspection.
55 C 6-501.16: After use, mops shall be placed in a position that allows them to air-dry without soiling walls, EQUIPMENT, or supplies.
Observed the one of the mops to be left on the floor of the mop sink. Correct and maintain by next routine inspection. Repeat
55 C 6-501.12: (A)PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean.(B)Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
Floor under the dish machine had a lot of debris. Clean and maintain by next routine inspection. Repeat
55 C 6-501.11: PHYSICAL FACILITIES shall be maintained in good repair.
Observed a few ceiling tiles missing throughout the kitchen. Provide and maintain by next routine inspection. Repeat
56 C 6-501.110: (A) Dressing rooms shall be used by EMPLOYEES if the EMPLOYEES regularly change their clothes in the establishment. (B) Lockers or other suitable facilities shall be used for the orderly storage of EMPLOYEE clothing and other possessions.
Observed and employees personal bag and a phone to be stored on or around the food prep table. Correct and maintain by next routine inspection.
Inspection Comments   KELLY'S LICENSE EXPIRES THIS YEAR PLEASE RENEW IF NEEDED. FACILITY DOES HAVE FOUR OTHER CFPM LICENSE HOLDERS.
HACCP Topic: PROPER THAWING PRACTICES.
 

Person In Charge

  JOE A 		 

Date:

  01/28/2021
 

Inspector

  Angela Colon 		 

Follow-up:  Yes   No   Follow-up Date: